800-543-9038 USA866-805-7089 CANADA203-791-8396 LATIN AMERICA / CARIBBEAN2Technical DataServicechilled, hot water, 60% glycol,steam to 50 psiFlow characteristicmodified equal percentage, unidirectionalControllable flow range82°Sizes2” to 30”Type of end fittingfor use with ASME/class 125/150 flangeMaterialsBodyDiscSeatShaftGland sealBushingscarbon steel full lug316 stainless steelRPTF17-4 PH stainlessPTFEglass backed PTFEMedia temperature range-20°F to 400°F [-30°C to 204°C]Body pressure ratingANSI Class 150 Close-off pressure285 psiRangeability100:1 (for 30 deg to 70 deg range)Maximum velocity32 FPSLeakagebubble tight• Bubble tight shut-off to ANSI Class 150 Standards• Long stem design allows for 2” insulation minimum• Valve Face-to-face dimensions comply with API 609 & MSS-SP-68• Designed to be installed between ASME/ANSI B16.5 Flanges• Completely assembled and tested, ready for installationApplicationThese valves are designed to meet the needs of HVAC and Commercial applications requiring positive shut-off for liquids at higher pressures andtemperatures. Typical applications include chiller isolation, cooling towerisolation, change-over systems, large air handler coil control, bypass andprocess control applications. The large C values provide for an economicalcontrol valve solution for larger fl ow applications.Dead End ServiceFollow all described pre-installation and installation procedures. Valves are capable of bubble tight, dead end closure with either the upstream ordownstream fl ange removed.ValveNominal SizeTypeSuitable ActuatorsCv 90°Cv 60°IN2-waySpringNon-Spring10252”F650-150SHP AF SeriesM SeriesY Series146802½”F665-150SHP 2281253F680-150SHP 4512484F6100-150SHP 143925”F6125-150SHP 11036076F6150-150SHP 20611358F6200-150SHP 351719310F6250-150SHP 4837266012”F6300-150SHP 685735924”F6350-150SHP 9287486516”F6400-150SHP 11500327018”F6450-150SHP 14420759020”F6500-150SHP 220501155024”F6600-150SHP 343881801230”F6750-150SHP MODON/OFFValveSize10°20°30°40°50°60°70°80°90°F650-150SHP2”1021.506.101263956779102F665-150SHP½1462.208.8023755811042146F680-150SHP3”2283.4014325787125171221228F6100-150SHP4”4516.802763114171248338437451F6125-150SHP5”7141143100180271393536693714F6150-150SHP6”1103176615427841960782710701103F6200-150SHP8”206431122895207841135154820022064F6250-150SHP10”35175321149288613361934263834113517F6300-150SHP12”483773290677121918382660362846924837F6350-150SHP14”6857103411960172826063771514366516857F6400-150SHP16”92871395571300234035295108696590089287F6450-150SHP18”11400171684159628734332627085501105811400F6500-150SHP20”144202168652019363454807931108151398714420F6600-150SHP24”22050331132330875557837912128165382138922050F6750-150SHP30”343884911965458582531244518012245633275034388F6 Series 2-Way, ANSI Class 150 Butterfly ValveReinforced Tefl on Seat, 316 Stainless Disc50904 - 02/12 - Subject to change. © Belimo Aircontrols (USA), Inc.800-543-9038 USA866-805-7089 CANADA203-791-8396 LATIN AMERICA / CARIBBEAN27Maximum Dimensions (Inches)ValveSizeCv 90°ABCD(Max)BHCNo. of HolesLug BoltActuatorClose-Off (PSI)F650-150SHP2101.759.009.0019.504.755/8-11 UNC2*AF150pring ReturnF665-150SHP2½”1461.889.009.0020.005.505/8-11 UNC150F680-150SHP3”2281.929.009.0020.506.005/8-11 UNC150F6100-150SHP4”4512.139.009.0021.007.505/8-11 UNC150F650-150SHP1021.759.009.0019.504.755/8-11 UNCGK285lectronic Fail-SafeF665-150SHP2½”1461.889.009.0020.005.505/8-11 UNC285F680-150SHP32281.929.009.0020.506.005/8-11 UNC285F6100-150SHP4”4512.139.009.0021.007.505/8-11 UNC150F6100-150SHP4”4512.139.009.0021.007.505/8-11 UNC2*GK285F650-150SHP21021.759.009.0019.504.755/8-11 UNCGM285on-Spring ReturnF665-150SHP½”1461.889.009.0020.005.505/8-11 UNC285F680-150SHP3”2281.929.009.0020.506.005/8-11 UNC285F6100-150SHP44512.139.009.0021.007.505/8-11 UNC150F6100-150SHP4”4512.139.009.0021.007.505/8-11 UNC2*GM285F650-150SHP21021.758.008.0022.254.755/8-11 UNCSY2…285F665-150SHP2½”1461.888.008.0022.755.505/8-11 UNC285F680-150SHP3”2281.928.008.0023.006.005/8-11 UNC285F6100-150SHP4”4512.138.008.0023.757.505/8-11 UNC285F6125-150SHP5”7142.258.008.0024.258.503/4-10 UNC285F6150-150SHP6”11032.298.008.0024.759.503/4-10 UNC285F6200-150SHP820642.5012.0012.0032.0011.753/4-10 UNCSY3…150SY4…285F6250-150SHP10”35172.8112.0012.0033.0014.25127/8-9 UNCSY4…285F6300-150SHP12”48373.2312.0012.0035.0017.00127/8-9 UNCSY4…150SY5…285F6350-150SHP14”68573.6214.0014.0036.0018.75121-8 UNCSY5…150SY7…285150F6400-150SHP16”92874.0014.0014.0037.5021.25161-8 UNCSY8…285F6450-150SHP1811404.5014.0014.0042.2522.7511 1/8-8 UNCSY7…150SY8…285F6500-150SHP20”144205.0014.0014.0049.5025.00201 1/8-8 UNCSY8…150SY10…285F6600-150SHP24”220506.0614.0014.0056.2529.50201 1/4-8 UNCSY10…150F6750-150SHP30”343886.7514.0014.0066.5836.00281 1/4-8 UNCSY12…125F6 Series 2-Way, ANSI Class 150 Butterfl y ValveReinforced Tefl on Seat, 316 Stainless DiscDimension “A” does not include flange gaskets. (2 required per valve)Application Notes1. Valves are rated at 285 psi differential pressure in the closed position@ 100°F media temperature.2. Valves are furnished with lugs tapped for use between ANSI Class 125/150 flanges conforming to ANSI B16.5 Standards.3. 2-way assemblies are furnished assembled, calibrated and tested, ready forinstallation.4. Dimension “D” allows for actuator(s) removal without the need to remove thevalve from the pipe.5. Weather shields are available, dimensional data furnished upon request.6. Flange gaskets (2 required, not provided with valve) MUST be used betweenvalve and ANSI flange.7. Flange bolts are not included with the valve. These are furnished by others.DimensionsDBCABHC102SHP series valves have a preferred flow direction.PreferredFlowrate50904 - 02/12 - Subject to change. © Belimo Aircontrols (USA), Inc.800-543-9038 USA866-805-7089 CANADA203-791-8396 LATIN AMERICA66ModelsGMX24-MFT-X1Technical DataPower supply24 VAC ± 20% 50/60 Hz24 VDC ± 10%Power consumptionrunning4.5 Wholding2 WTransformer sizing7 VA (class 2 power source)Electrical connection3 ft, 18 GA appliance cable, 1/2” conduit connectorOverload protectionelectronic throughout 0 to 95° rotationControl signal2 to 10 VDC, 4 to 20 mA (with 500 W, 1/4 W resistor) ZG-R01Input impedance100 k W for 2 to 10VDC (0.1 mA) 500 W for 4 to 20 mA750 W for PWM1500 W for on/off and floating pointAngle of rotationmechanically limited to 95°Direction of rotationreversible with switch A/BPosition indication0 to 1 and reversible indicatorRunning time150 sec.Humidity5 to 95% RH non-condensingAmbient temperature-22°F to 122°F [-30°C to 50°C]Storage temperature-40°F to 176°F [-40°C to 80°C]Housing NEMA 2/IP54Housing materialUL94-5VA (flammability rating)Agency listingscULus according to UL60730-1A/-2-14, CAN/CSA E60730-1, CSA C22.2 No.24-93, CE according to 89/336/EECNoise level max. 45 dB (A)Servicingmaintenance freeQuality standardISO 9001GMX24-MFT-X1 Actuators, Multi-Function TechnologyDimensions with 2-Way ValveDBCABHCDimensions (Inches)Non-Fail Safe (psi)ValveSizeABCD(Max)BHCGM2*GMF680HD3”1.699.009.0020.506.00200F6100HD4”1.929.009.0021.007.50200F6100HDU4”1.929.009.0021.007.5050F6125HDU5”2.089.009.0022.008.5050F6150HDU6”2.089.009.0022.509.5050F650-150SHP2”1.759.009.0019.504.75285F665-150SHP2½”1.889.009.0020.005.50285F680-150SHP3”1.929.009.0020.506.00285F6100-150SHP4”2.139.009.0021.007.50150285F650-300SHP2”1.759.009.0019.505.00285400F665-300SHP2½”1.889.009.0020.005.88285400F680-300SHP3”1.929.009.0020.506.63285400F6100-300SHP4” 2.139.009.0021.007.88150285Dimensions with 3-Way Valve100100DABCDimensions (Inches)Non-Fail Safe (psi)ValveSizeABCD(Max)BHCGM2*GMF765HD2½”5.006.706.7016.005.50200F780HD3”5.507.207.2016.256.00200F780HDU3”5.507.207.2016.256.0050F7100HD4”6.508.458.4517.007.50200F7100HDU4”6.508.458.4517.007.5050F7125HDU5”7.509.609.6017.508.5050F7150HDU6”8.0010.0810.0818.009.5050F750-150SHP2”4.506.256.2516.504.75150285F765-150SHP2½”5.006.886.8817.005.50150285F780-150SHP3”5.507.427.4217.506.00150285F7100-150SHP4”6.508.638.6318.007.50150F750-300SHP2”5.006.756.7515.505.00285F765-300SHP2½”5.507.387.3816.005.88285F780-300SHP3”6.007.927.9216.256.63285F7100-300SHP4”7.009.139.1318.007.88150AM_GM_LineRevisedD101M40048 - 06/10 - Subject to change. © Belimo Aircontrols (USA), Inc.800-543-9038 USA866-805-7089 CANADA203-791-8396 LATIN AMERICA67Wiring Diagrams3Actuators may also be powered by 24 VDC.5Actuators with plenum rated cable do not have numbers on wires; use color coded instead. Actuators with appliance rated cable use numbers.8Control signal may be pulsed from either the Hot (Source) or Common (Sink) 24 VAC line.10For triac sink the Common connection from the actuator must be connected to the Hot connection of the controller.Meets cULus or UL and CSA requirements without the need of an electrical ground connection.9Contact closures A & B also can be triacs. A & B should both be closed for triac source and open for triac sink.11Position feedback cannot be used with a Triac sink controller. The actuator internal common reference is not compatible. WARNING Live Electrical Components! During installation, testing, servicing and troubleshooting of this product, it may be necessary to work with live electrical components. Have a qualified licensed electrician or other individual who has been properly trained in handling live electrical components perform these tasks. Failure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury.GMX24-MFT-X1 Actuators, Multi-Function Technology7Blk (1) CommonRed (2) + HotWht (3) Y1 Input, 2 to 10VOrg (5) U Output, 2 to 10V4 to 20 mAor2 to 10 VDCControl SignalLineVolts24 VAC Transformer(+) (–)Ω500Ω1/4 watt35CCW CWW545_No_2VDC/4-20 mABlk (1) CommonRed (2) Hot Wht (3) Y InputOrg (5) U Output LineVolts24 VAC/DC TransformeraPosition Feedback VDC(+)(–)3W545_No_2Two PositionCCWCWAB5CCWCWAB5Direction of rotation switchLineVolts2 to 10 VDCFeedback Signal24 VAC TransformerBlk (1) Common –Red (2) Hot +Wht (3) Y1 InputOrg (5) U Output 2 to 10VPnk (4) Y2 Input 83AB91011W545_No_2Floating PointBlk (1) CommonRed (2) + HotWht (3) Y InputOrg (5) U Output LineVolts24 VAC Transformer (AC only)(+)(–)8PositionFeedback VDCW545_No_2PWMBlk (1) CommonRed (2) + HotWht (3) Y Input, 2 to 10 VOrg (5) U Output 2 to 10 VCCW CWMasterCCW CWSlave24 VAC TransformerLine VoltsControl Signal 2 to 10 VDC (–)(+)35Blk (1) CommonRed (2) + HotWht (3) Y Input, 2 to 10 VOrg (5) U 5Master_SlaveMaster/SlaveM40048 - 06/10 - Subject to change. © Belimo Aircontrols (USA), Inc.Next >